| |
|
And They're
Off! |
|
Issue #3 |
July 2001 |
|
|
After almost
eight months of rest, relaxation, and rebuilding, team scR took to the
track this past weekend at the Mid-Ohio Sports Car Course. With so
much time out of the seat, the team certainly expected the cobwebs to
be hanging around for most of the Double Regional, but it didn't take
long before the red SC2 was up to speed once again. Looks like we're
in for another exciting year!
Rebuilding
Following the ARRC in November, the race car was unceremoniously
parked in Tom's garage until we pulled off the cover in March.
Unfortunately, we were greeted by a quart of power steering fluid on
the floor and a heavy layer of dust, but otherwise the car was ready
for surgery.
Phase one involved basic chassis work. We started by rebuilding all
four shocks, increasing rear spring rates, and swapping in an SPS 16mm
adjustable rear anti-sway bar. New wheel bearings, front hubs, and
lug studs were followed by a complete replacement of the power
steering system (pump, reservoir, and hoses).
Since we suspected that the early demise of the power steering system
was related to the high-RPM operation of the ITA-spec motor, we
elected to fabricate underdrive pulleys to slow things down a bit.
Ironically, this turned out to be the biggest engineering project of
the rebuild - trying to find a belt to work with our custom
combination of water pump, alternator, and power steering pulleys was
a challenge all its own. The final product, however, is a work of
art.the guys at Big Sky Motorsports sure can spin up some beautiful
parts when needed.
Phase two involved working with the R&D lab at Energy Suspension to
develop a complete chassis bushing kit. While the installation went
relatively quickly, a few bugs are still being ironed out for
production. Word on the street is that bushings should be available
for sale later this summer, but our prototype set has been nothing but
perfect so far.
Phase three focused on addressing our horsepower-to-weight ratio.
Taking advantage of new rule changes for 2001, we managed to remove an
additional thirty pounds from the car, bringing us right to our
minimum weight! To help things out even more, the guys at Big Sky
stepped up again and built revised intake and exhaust system
components which shaved another ten pounds while bumping us up another
three horsepower. Time to see how this thing runs!
New Season, Familiar Faces
For our first event of 2001 we were teamed up with two familiar
faces. Mark Rushbrook and the R^3 Motorsports team (that's short for
Rushbrook Racing Research) had their #21 SC2 locked and loaded for the
new season with a Womack-built motor and a Quaife differential,
bringing it to the same spec as the #34 car. Vaughan Scott of PUB
Racing (don't ask - it's a Porsche thing) had his 924 running at 100%
and was ready for his first run at a "big" racetrack. Everyone had
their sights set high as we slowly headed down to the false grid.
Mid-Ohio Qualifying, Saturday
Picking up where we left off last year, rain began to fall on the
windshield as we idled through the paddock. This was not a surprise,
as it had been raining off and on all morning, but of course we had
committed to our dry tires and chassis set-up for the session. Here
we go again.
As we headed out on the track we quickly discovered that the racing
line was dry enough to turn in relatively fast lap times, so right
foot to the floor! One by one the cobwebs were swept away as the #34
picked its way through the qualifying field. Due to the changing
conditions and the large size of the field (thirty two cars, all in
ITA!), we were never able to turn in a real "flier," but still
managed to qualify 4th in class. Not bad for a thirty two car field.
Unfortunately, while the #34 car was making progress through the
field, the #21 car developed a case of the "oil doesn't want to stay
in the engine" syndrome. Waving away billowing oil clouds, the R^3
crew discovered that an oil line fitting had come lose and had
deposited several cups of oil across the engine, transmission, cradle,
and, well, you get the idea. Three cans of Brakleen, two rolls of
paper towels, and four hours of scrubbing later the team was ready to
head back out, but their truncated qualifying session left them 30th
on the grid, right behind Vaughan and his Porsche.
Not that both teams didn't have enough to do already, both SC2's
managed to violate the SCCA's maximum noise level of 103 dB (both cars
blew 105's). Remember those fancy Big Sky exhaust systems? They were
removed and replaced with last year's hardware.boo hiss. Take away
two HP and add ten pounds, please.
Mid-Ohio Race, Saturday
In so many words, the Saturday race was boring.at least from our
seat. At the start we very quickly fell into single file formation,
neither gaining nor losing any positions. On lap two, the #9 car in
running in 3rd place spun in turn 13, allowing us a short-lived podium
opportunity. That would be erased, however, as he made up the time
and then some, relegating us to finish where we had started - 4th.
But hey, we were just shaking off cobwebs, right? Our best lap time,
a 1:47.9, was still over one second faster than we had run in
qualifying.
Back in the pack, the R^3 Motorsports team was running a 1-stop
strategy. After moving up from 30th to 22nd in two laps, Mark brought
the #21 into pit lane to pop the hood and look for oil gremlins. None
were found, so John slammed the hood and sent the car back out on
track. Over the ensuing ten laps, Mark would have a blast, passing
eleven cars on the way to his 20th place finish!
The evening was spent telling tall tales over Sam Adams at the
Outback. Mark's lap times would have placed him in the top eight that
afternoon, so the expectations were high for a pair of Saturns in the
top-five on Sunday.
Mid-Ohio Qualifying, Sunday
On Sunday, the rain was thoughtful enough to wait until the 5-minute
warning was given on the false grid to fall. No joke. A collective
sigh was heard from the field as we stared in amazement at the rain
falling in spite of the sunshine. Like Saturday, however, the track
was clear and dry as we ran out to turn in our best times possible.
Midway through the session, the #34 and #21 cars were separated by a
lone Honda CRX, but the miniature freight train ran laps clear of
traffic. Positions were swapped sparingly as the group tried to work
together to make the best of the open track. The #34 car developed a
push early in the session that never went away, but without time to
make an adjustment we simply drove around it the best we could.
When the results were posted we were disappointed to see that we had
fallen to 5th on the grid, but we were starting right next to the #21
car in 6th! Row three was a Saturn convention in the middle of Honda
land.
Mid-Ohio Race, Sunday, play-by-play
- Coming around the carousel it is #34 paired up with #21 at the green
- #34 goes low toward turn 1, allowing #26 (Honda) to run between #34
and #21
- #34, #26, and #21 are three wide running into turn 1
- #34 runs the inside of turn 1, exiting in front of #26
- #21 runs the outside of turn 1, exiting in front of #26
- #34 continues to run the inside of the track, passing #96 (Honda)
for 4th
- By turn 6 it is #34 (4th), #96 (5th), and #21 (6th) nose-to-tail
- In turn 13, #9 (running in 3rd) loses brakes and exits the course
- At the end of lap 1 it is #34 (3rd), #96 (4th), and #21 (5th)
- Going into turn 5, #96 goes wide and is passed by #21
- At the end of lap two it is #34 (3rd) and #21 (4th)
- In turn 5, #21 misses the brake pedal (!) and is passed by #26 and
#12
- At the end of lap 5, it is #34 (3rd), #12 (4th), #26 (5th), and #21
(6th)
And that, ladies and gentlemen, is how the race ended 8 laps later.
Heading Home
So, for our first outing of the season we came home with a 4th and a
3rd, kept the car in one piece, and managed to avoid the rain which
fell in buckets immediately after we left the track. Mark and his
team solved their oiling issues, ran in front all day, and only needed
to stock up on Brakleen for the next event while Vaughan took copious
notes on how to go fast on a "big" track (hint: engine). What a great
weekend!
All that's left to ask is, "What's next?" Since we love Mid-Ohio so
much, our next outing will be July 27-29 back in Lexington. We should
have another small trick or two up our sleeves (we need to make that
new exhaust system work!), but even if we keep running at this pace
all year, that's not such a bad thing either.
See you at the track!
 |
|
|
|
|
